Product ID:INDUSTRIAL ENAMEL-LOW VOC TOPCOATS, 7665
MSDS Date:02/13/1989
FSC:8010
NIIN:00N022928
MSDS Number: BLTTZ

RUST-OLEUM CORP

11 HAWTHORN PARKWAY
VERNON HILLS, IL 60061
US

Emergency Phone: 312-367-7700; 312-864-8200

Info Phone: 312-367-7700

Preparer: PROD SAFETY COORDINATOR

Cage: 08882

RUST-OLEUM CORP

VERNON HILLS, IL 60061-1583 US

Telephone: 847-367-7700

Cage: 08882

2 @ 20C

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 24-45%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM; 9293

TITANIUM OXIDE; (TITANIUM DIOXIDE)

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 0-20%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: HARMFUL IF INHALED. MAY
AFFECT THE BRAIN & NERVOUS SYSTEM CAUSING DIZZINESS,
HEADACHE/NAUSEA. REPEATED OVEREXPOSURES MAY LEAD PROGRESSIVELY TO
STAGGERING GAIT, CONFUSION, UNCONSCIOUSNESS OR COMA. CAUSES NOSE &
THROAT IRRIT. SKIN/EYE: CAUSES EYE AND SKIN IRRIT WHICH MAY LEAD TO
DERMATITIS (EFTS OF OVEREXP)
Effects of Overexposure:HLTH HAZ: WITH REPEATED OVEREXPOSURE. INGEST:
GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING; AND DIARRHEA.
CHRONIC: REPORTS HAVE SHOWN REPEATED AND PROLONGED OCCUPATIONAL
OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN AND NERVOUS SYSTEM
DAMAGE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:FUMES(INHAL): REMOVE FROM EXPOSURE, RESTORE BRTHG & NOTIFY
MD. SPRAY(EYES): FLUSH IMMED WITH LARGE AMOUNTS OF H*2O FOR AT
LEAST 15 MIN. NOTIFY MD. SPLASH(SKIN): WASH AFFECTED AREA WITH SOAP
AND H*2O, REMOVE CONTAMINATED CLTHG & WASH BEFOREREUSE. INGEST: DO
NOT INDUCE VOMITING. KEEP PERSON WARM, QUIET & GET MED ATTN. ASPIR
OF THIS MATL INTO LUNGS CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE
FATAL.

Flash Point Method:TCC
Flash Point:104F,40C
Extinguishing Media:NFPA CLASS B EXTINGUISHERS (CARBON DIOXIDE, DRY
CHEMICAL OR FOAM).
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL PROT
EQUIP . WATER SPRAY MAY BE INEFFECTIVE. WATER MAY BE USED TO COOL
CLOSED CONTAINERS TO PREVENT PRESS (SUPP DATA)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLOSED. ISOLATE FROM
HEAT/ELEC EQUIP/SPARKS/OPEN FLAME. CLOSED CNTNRS MAY EXPLODE WHEN
EXPOS TO EXTREME HEAT. DO NOT APPLY TO HOT SURFACES.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION, VENTILATE AREA
AND REMOVE WITH INERT ABSORBENT AND NON-SPARKING TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DO NOT STORE ABOVE 120F. STORE LRG
QTYS IN BLDGS DESIGNED & PROT FOR STORAGE OF NFPA CLASS II COMBUST
LIQUIDS. CNTNRS SHOULD BE GROUNDED WHEN POURING.
Other Precautions:EMPTY CONTAINERS MAY BE HAZARDOUS. ACCORDING TO
PENNSYLVAINA/NEW JERSEY RIGHT-TO-KNOW LAWS, OTHER INGREDIENTS IN
THESE PRODUCTS SUCH AS RESIN, PIGMENT AND ADDITIVES ARE
NONHAZARDOUS AND CONSIDERED TRA DE SECRETS UNDER THESE REGULATIONS.

Respiratory Protection:USE NIOSH/MSHA APPROVED CHEMICAL CARTRIDGE
RESPIRATOR (TC23C) TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY
AND ORGANIC VAPORS DURING SPRAY APPLICATION. IN CONFINED AREAS: USE
NIOSH/MSHA APPROVED SU PPLIEFD-AIR RESPIRATOR OR HOODS (TC19C).
Ventilation:PROVIDE GENERAL DILUTION OR LOCAL EXHAUST VENT IN VOLUME &
PATTERN TO KEEP TLV OF INGRED BELOW ACCEPTABLE LIMITS.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHTING PROC: BUILD-UP AND POSSIBLE AUTOIGNTION OR EXPLOSION. IF
WATER IS USED, FOG NOZZLES ARE PREFERRED.

HCC:F4
Boiling Pt:B.P. Text:307F,153C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:0.9-1.4
Evaporation Rate & Reference:SLOWER THAN EHTER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:47-54

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY OPEN FLAME: CARBON MONOXIDE AND
CARBON DIOXIDE.

Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL, STATE AND FEDERAL
REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.